[冷熱沖擊試驗箱]冷熱沖擊試驗箱設備的自我檢修維護方法

　　冷熱沖擊試驗箱設備主要是針對于電工、電子產品，以及其原器件，及其它材料在高溫、低溫速變的環境下貯存、運輸、使用時的適應性試驗。適用標準：GB/T5170.5-2008、GB/T10586-2006、GB/T2423.1-2008試驗A、GB/T2423.2-2008試驗B、GB/T2423.3-2006試驗、GB/T2423.4-2008試驗等。

　　1.認真檢查各級氣缸和運動機件的動作聲音根據“聽”辨別它的工作情況是否正常，如果發現不正常的聲音立即停機檢查;

　　2.注意各級壓力表，儲氣罐及冷卻器上的壓力表和潤滑油壓力表的指示值是否在規定的范圍內;

　　3.注意電機的溫升、軸承溫度和電壓表、電流表指示情況是否正常，電流不得超過電動機額定電流，若超過時，要找原因或停機檢查;

　　4.經常檢查電機內有無雜物甚至導電物體，線圈有否被損壞，定子、轉子有否摩擦，否則電動機啟動后會使電機燒壞;

　　5.若為水冷式壓縮機若斷水后不能立即通入水要避免因冷熱不均發生氣缸裂紋。在冬季停車后要放掉冷卻水以免氣缸等處凍裂;

　　6.檢查冷卻水溫度、流量是否正常;

　　7.檢查潤滑油供情況，運動機構的潤滑系統供油情況(有些壓縮機在機身十字頭導軌側面裝有有機玻璃檔板，可以直接看到十字頭運動及潤滑油的供應情況);氣缸、填料可用單向伐作放油檢查，可以檢查注油器向氣缸中注油情況;

　　8.觀察機身油池的油面和注油器中的潤滑油是否低于刻度線如低時應及時加足(用油尺的須停車檢查);

　　9.用手感觸檢查機身曲軸箱十字導軌處吸排氣伐蓋等處溫度是否正常;

　　10.檢查壓縮機是否振動、地腳螺釘有無松動和脫落現象;

　　11.檢查壓力調節器或負荷調節器，安全伐等是否靈敏;

　　12.注意壓縮機和所屬設備和環境的衛生;

　　13.儲氣罐、冷卻器、油水分離器都要經常放出油水;

　　14.所用潤滑機要沉淀過濾。冬季與夏季壓縮機油要區別使用。

　　廣東劍喬試驗設備有限公司是專注于振動及環境試驗設備研發、生產、銷售大型生產廠家，主營產品：振動臺、振動試驗機、振動試驗臺、沖擊試驗臺、沖擊試驗機、老化房、恒溫恒濕試驗室、恒溫恒濕機、快速溫變試驗箱、高低溫試驗箱、冷熱沖擊試驗箱、冷熱沖擊箱、恒溫恒濕箱、恒溫恒濕試驗箱等產品。